Back to all

Tuffy Sturgis Service for Your Exhaust System

March 22, 2020

Your vehicle's exhaust system is more than just a tailpipe and a muffler. In fact, it is one of the most complex systems on your vehicle.

drive

The manifold is attached to the vehicle engine. It collects exhaust from the cylinders and directs it into the exhaust pipe. Gaskets seal the connection of the manifold to the engine and to other joints. A cracked or loose manifold or a leaking or damaged gasket can allow dangerous gases to enter the passenger compartment of a vehicle. One of these gases is carbon monoxide, which is colorless, odorless and deadly. For this reason, it is important Battle Creek residents keep their exhaust system in good repair.


The pipes that connect the various parts of the exhaust system can rust or be damaged by rocks or other road debris. Such damage can cause dangerous gases to leak into the air.

The catalytic converter is the next component of your vehicle exhaust system. It sort of looks like a muffler. Its job is to change dangerous gases into harmless carbon dioxide and water. The catalytic converter doesn't require any regular maintenance, but it can wear out. If it fails, you will need a new catalytic converter to pass an emissions test in Michigan. Call Tuffy Sturgis at 269.651.7713 if you suspect a problem with your catalytic converter.

Oxygen sensors in the exhaust pipe monitor the oxygen content of the exhaust. This helps the vehicle engine's computer keep the fuel-to-air mixture at optimal levels.

The muffler is also part of your vehicle exhaust system, but it deals with a different kind of emission. It keeps your vehicle from emitting bad sounds. Mufflers act like finely tuned musical instruments. They create a feedback of sound waves to absorb or decrease the noises made by your engine. Different mufflers can create different sound waves, so you can actually “tune” your car to produce a particular sound, anything from whisper to rumble.

It is important that damaged mufflers be replaced immediately at your Sturgis automotive service center, especially if they are leaking. Not only will the extra noise annoy your Sturgis neighbors, a leaky muffler could be serious.

The entire exhaust system is attached to your vehicle by hangers and clamps. These fasteners can rust, come loose or break. The components of the exhaust system can get very hot, so when the hangers or clamps fail, these hot components can come into contact with other parts such as wires and hoses. These can melt, causing serious and damage to your vehicle. Good car care requires that you have your exhaust system inspected regularly.

Caring for your vehicle exhaust system at Tuffy Sturgis yields cosmetic benefits like quieting your engine sounds, but also may impact your health and safety. Your life, or the life of a loved one, may actually be on the line.

Tuffy Sturgis
68864 S. Centerville Rd.
Sturgis, Michigan 49091
269.651.7713

 

Need Service?

Request a Quote

More articles from Tuffy Sturgis

Take Charge! (Battery Testing)

November 28, 2021

OK, so you probably take your vehicle's battery for granted. Turn the key or push a button and it starts right up. During times of warmer weather, you probably think your battery can take it easy. But it may surprise you to learn that hot weather can be much harder on a vehicle's battery than ... More

Steer Clear of Power Steering Problems (Power Steering Maintenance)

November 21, 2021

We usually take our vehicle's easy steering for granted until something goes wrong. Power steering is what makes it almost effortless to turn the steering wheel, aiming your vehicle in the direction you want to go. Without the assistance of power from the engine, steering would be a laborious pr... More

I Had No Idea! (Four Things You Didn't Know About Vehicles)

November 14, 2021

Bet you didn't know: Some of the earliest rearview mirrors were marketed as "Cop Spotters" so drivers would know when police were following them. Who wants a ticket, anyway? According to eBay Motors, Elmer Berger first patented a rearview mirror that was mounted on the front fenders, on the spare... More